Ultraviolet Light Fights New Virus
In the fight against the coronavirus disease 2019 (COVID-19) pandemic, an old weapon has re-emerged . More than a century after Niels Finsen won the 1903 Nobel Prize for discovering that ultraviolet (UV) light could kill germs , UV light is surging in popularity as a method for disinfecting hospital rooms and other public spaces.
Xenex is one of at least 30 companies making UV disinfection equipment. And not just for hospitals. Another company, Dimer UVC Innovations of Los Angeles, CA, USA, markets a cart with UV lamps, called GermFalcon (Fig. 2 ), that it claims can disinfect a whole airplane in 3?min . UV lamp
is also being used to disinfect and re-use hospital face masks .
UV light is generally divided into three classes, based on the wavelength of the light. All of them are invisible to the human eye. The longest wavelengths are UVA (315–400?nm) and UVB (280–315?nm), which are found in ordinary sunlight. These are the rays that can cause sunburn if one stays outside too long without protection. UVA and UVB light rays have limited germ-killing ability because viruses and bacteria have had millions of years to adapt to them.
But UVC light (200–280?nm) is completely absorbed by our atmosphere and never reaches the surface of the earth . Therefore, UVC light is just as novel to SARS-CoV-2 as the virus is to humans. According to the International Ultraviolet Association, it is generally accepted that a dose of 40?mJ·cm?2 of 254?nm light will kill at least 99.99% of “any pathogenic microorganism” , .
At present there are many different designs for 4 pin UV lamp
. Some systems consist of just a bare lightbulb and a timer, while others are mobile robots that can reach hard-to-access places . Two of the major design choices are the wavelength of light and the method of delivery. By far the most common wavelength for germicidal light is 254?nm, produced by low-pressure mercury lamps. These lamps are easy and cheap to manufacture because they use essentially the same technology as a fluorescent light bulb. A fluorescent bulb actually produces UV light inside the bulb. But the phosphor deposited on the glass surface of the bulb absorbs that light and re-emits it at longer wavelengths that humans can see. To make a UV lamp, the glass is replaced with a material transparent to UV light, such as fused quartz.
However, 254?nm may not be the optimal wavelength for killing all viruses. Experts believe that different wavelengths disable viruses in different ways , . The 254?nm light damages the viral deoxyribonucleic acid (DNA) or ribonucleic acid (RNA) so that the virus cannot reproduce. Shorter wavelengths, like 207–222?nm (sometimes called “far UVC”) are believed to damage the proteins on the surface of the virus that it needs to attach to human cells. Thus, the curve that describes the viral killing ability of UVC light has a double-humped shape, with a peak at shorter wavelengths and another around 265?nm.
The Xenex system is designed to take advantage of both virus-killing methods, by producing light from a pulsed xenon source that spans the whole spectrum from 200 to 315?nm. Because xenon is an inert gas, xenon-stimulated bulbs can be disposed of more easily than ones containing toxic mercury. According to the company, more than 500 healthcare facilities around the world are currently using Xenex robots for whole-room disinfection.
Disinfection with far-UVC lamps remains largely experimental but could have an intrinsic advantage. Initial evidence suggests that far-UVC light does not penetrate beyond the outer dead layer of skin cells or the liquid film on eyes in healthy people , . Thus, it cannot cause skin cancer or cataracts, like 2 pin UV lamp
. It also seems not to cause temporary skin burns and eye damage (“welder’s flash”) like standard UVC. This presumably depends on the intensity of exposure; whether intense exposure to destroy pathogens on the hands, for example, would be safe is unknown.
However, doctors may need some convincing to accept that some kinds of UV light may be safe to human eyes. “I would like to see more research on longer term exposure before I am convinced,” said Karl Linden, a professor of environmental engineering at the University of Colorado in Boulder, CO, USA. If it can be proven safe at the incidental exposure involved, far UVC light might prove ideal for disinfecting spaces that always have people in them, like a 24-hour market; they could perhaps also be used to provide constant disinfection in hospitals.
No matter what wavelength is used, germicidal light has another problem to overcome: If a surface is in shadow, it will not be disinfected. Shadows abound in a typical hospital room, with multiple surfaces and objects that jut out at odd angles from the floor, walls, and ceiling. In one recently published study, when a standard UVC lamp was placed in the center of the room and operated according to the manufacturer’s instructions, some places like the wardrobe and the sink were partly or completely in shadow, and did not receive the full dose of 40 mJ·cm?2 needed to assure 99.99% disinfection .
For this reason, many systems have to be moved to a few different places to thoroughly disinfect a room with UVC light. This means a housekeeper has to enter the room, position the lamps, leave the room, turn them on for 5?min or so, then re-enter the room, reposition the device, and so on. It is a laborious process. To address this shortcoming, UVD Robots, a company based in Odense, Denmark, has developed a U lamp
that moves around the room autonomously, eliminating the need for manual repositioning. According to a UVD Robots spokesperson, the company recently sold “a three-digit number” of their robots to Sunay Healthcare Supply (also in Odense) for use in China, and these robots are now available to 2000 Chinese hospitals . The company says its robots are being used in more than 50 countries in all six inhabited continents.
If UV disinfection is so good, why has it taken so long to be embraced by hospitals, and why is it virtually unknown to other businesses (outside of wastewater treatment, where it has been used for decades)? It has a lot to do with human perceptions, said Edward Nardell, a professor of environmental health, immunology, and infectious diseases at the Harvard T.H. Chan School of Public Health in Cambridge, MA, USA. “The first barrier is fear. Everyone has heard doctors say that we should not be exposed to too much UV. That UVC penetrates skin and eyes poorly is too nuanced a difference. Lack of familiarity is a second reason. Engineers and architects do not hear about germicidal light in their training. It is an orphan discipline.”
UV light may also suffer from a quirk of history . In the 1940s and 1950s, antibiotics came into wide use, giving many doctors the impression that the war against microbes was won. UV light, therefore, was not only an orphan technology but also seemed obsolete. However, that complacency began to unravel in the 1980s, when drug-resistant bacteria emerged, particularly tuberculosis (TB). Nardell said that a partial solution to disrupt hospital transmission of TB, an airborne pathogen, used louvered UVC lamps to disinfect the air near the ceiling, which was then circulated to the rest of the room. But that strategy did not affect pathogens that depend on surface-based transmission. Hospital-acquired infections remain a major problem globally, affecting an estimated seven to ten of every 100 hospitalized patients . Many of the pathogens that cause these infections are multi-drug resistant and difficult or impossible to cure with drugs, so it makes sense to try to kill them before they can enter the body. Thus, before 2020, hospitals were the main customers for whole-room UV disinfection.
But now COVID-19 has arrived and changed everything. “With the new coronavirus, the demand outside hospitals has soared,” said Stibich. “We’ve deployed at hotels, offices, anywhere there is a high perceived risk, or they want extra assurance. As countries re-open, these other areas are going to.
Ultraviolet light is a type of electromagnetic radiation that makes black-light posters glow, and is responsible for summer tans — and sunburns. However, too much exposure to UV radiation is damaging to living tissue.
Electromagnetic radiation comes from the sun and transmitted in waves or particles at different wavelengths and frequencies. This broad range of wavelengths is known as the electromagnetic (EM) spectrum. The spectrum is generally divided into seven regions in order of decreasing wavelength and increasing energy and frequency. The common designations are radio waves,microwaves, infrared (IR), visible light, ultraviolet (UV), X-rays and gamma-rays.
Ultraviolet (UV) light falls in the range of the EM spectrum between visible light and X-rays. It has frequencies of about 8 × 1014 to 3 × 1016 cycles per second, or hertz (Hz), and wavelengths of about 380 nanometers (1.5 × 10?5 inches) to about 10 nm (4 × 10?7 inches). According to the U.S. Navy's "Ultraviolet Radiation Guide," UV is generally divided into three sub-bands:
UV radiation has enough energy to break chemical bonds. Due to their higher energies, UV photons can cause ionization, a process in which electrons break away from atoms. The resulting vacancy affects the chemical properties of the atoms and causes them to form or break chemical bonds that they otherwise would not. This can be useful for chemical processing, or it can be damaging to materials and living tissues. This damage can be beneficial, for instance, in disinfecting surfaces, but it can also be harmful, particularly to skin and eyes, which are most adversely affected by higher-energy UVB and UVC radiation.
Most of the natural UV light people encounter comes from the sun. However, only about 10 percent of sunlight is UV, and only about one-third of this penetrates the atmosphere to reach the ground, according to the National Toxicology Program (NTP). Of the solar UV energy that reaches the equator, 95 percent is UVA and 5 percent is UVB. No measurable H lamp
from solar radiation reaches the Earth's surface, because ozone, molecular oxygen and water vapor in the upper atmosphere completely absorb the shortest UV wavelengths. Still, "broad-spectrum ultraviolet radiation [UVA and UVB] is the strongest and most damaging to living things," according to the NTP's "13th Report on Carcinogens."
A suntan is a reaction to exposure to harmful UVB rays. Essentially, a suntan results from the body's natural defense mechanism kicking in. This consists of a pigment called melanin, which is produced by cells in the skin called melanocytes. Melanin absorbs UV light and dissipates it as heat. When the body senses sun damage, it sends melanin into surrounding cells and tries to protect them from sustaining more damage. The pigment causes the skin to darken.
"Melanin is a natural sunscreen," Gary Chuang, an assistant professor of dermatology at Tufts University School of Medicine, told Live Science in a 2013 interview. However, continued exposure to UV radiation can overwhelm the body's defenses. When this happens, a toxic reaction occurs, resulting in sunburn. UV rays can damage the DNA in the body's cells. The body senses this destruction and floods the area with blood to help with the healing process. Painful inflammation occurs as well. Usually within half a day of overindulging in the sun, the characteristic red-lobster look of a sunburn begins to make itself known, and felt.
Sometimes the cells with DNA mutated by the sun's rays turn into problem cells that don't die but keep proliferating as cancers. "The UV light causes random damages in the DNA and DNA repair process such that cells acquire the ability to avoid dying," said Chuang.
The result is skin cancer, the most common form of cancer in the United States. People who get sunburned repeatedly are at much higher risk. The risk for the deadliest form of skin cancer, called melanoma, doubles for someone who has received five or more sunburns, according to the Skin Cancer Foundation.
Other UV sources
A number of artificial sources have been devised for producing UV radiation. According to the Health Physics Society, "Artificial sources include tanning booths, black lights, curing lamps, germicidal lamps, mercury vapor lamps, halogen lights, high-intensity discharge lamps, fluorescent and incandescent sources, and some types of lasers."